Hickory Roof Pros provides professional tile roofing in Hickory, NC for residential and commercial properties across Catawba County and the Unifour. Tile is uncommon in the Catawba Valley. What exists here is mostly on older civic and church buildings and a handful of period houses, and almost all of the calls we take about it are underlayment calls rather than tile calls.
That distinction matters because tile does not keep water out on its own. It is a rain shield over a waterproof layer, and the waterproof layer is what ages. On a fifty-year-old clay roof the tile itself may be perfectly serviceable while the felt beneath it has turned to powder. Replacing broken pieces on a roof in that condition treats the symptom and leaves the leak.
The actual work is a lift and relay. Pieces come off in sequence, get sorted and stacked, the deck is repaired and re-underlaid with a high-temperature self-adhered membrane, and the sound tiles go back with new fasteners and battens where the profile calls for them. Breakage runs high on old clay, so we agree a replacement percentage and a sourcing plan for matching pieces before starting, not after.
Where tile meets a receiving plane the ordinary rules get stricter. Concentrated discharge onto a tile field drives water sideways under the courses at pressure, so those areas need the membrane carried well up and a proper valley or pan detail. A tile roof taking another roof's runoff without that detail will leak no matter how good the tile is. We have relaid sound tile twice on roofs where nobody addressed what was landing on them.
Now the part we will lose work by saying. Do not put a tile roof on a Hickory house that does not already have one. The rafter framing in the postwar and 1970s stock here was sized for asphalt, and clay or concrete tile multiplies that dead load several times over. Doing it properly means an engineer's evaluation and structural reinforcement, which turns a reroof into a project that crosses the $40,000 line in G.S. 87-1.
We are not saying tile is a bad roof. On the right building it is excellent and it will outlive everyone reading this. We are saying that on the specific housing stock of this valley the economics are poor, the structural questions are real, and the same budget spent on a proper asphalt or partial metal assembly buys you more roof. If a salesperson quotes a tile conversion without mentioning framing, that tells you something.
Our licensed and insured team brings the right materials and equipment to every job — kickout diverters soldered rather than caulked at the wall termination, self-adhered membrane run across the full receiving plane, headwall flashing tucked behind the wall covering on a two-story elevation, three by four downspout outlets set at the low end of the lower run, a doubled starter band laid in the impact strip below an upper eave, 26-gauge painted W-valley metal beneath an open valley cut — and backs the work with a written workmanship warranty. We serve Hickory and nearby communities including Newton, Conover, Long View, St. Stephens.
What We Handle
Everything our tile roofing in Hickory covers
One crew, one point of contact, and the full range of tile roofing work in Hickory, NC. If it is on this list we do it in house rather than handing it to a subcontractor:
- tile roof repair Hickory NC
- clay tile roof Catawba County
- concrete tile roof repair Hickory
- tile roof underlayment replacement
- broken roof tile replacement Hickory NC
- tile roof inspection Hickory
- historic tile roof North Carolina
- tile roof cost Hickory NC
- tile to shingle conversion Hickory
- tile roof leak repair Catawba County
- barrel tile repair Hickory NC
- tile roofer near me Hickory
Not sure which one describes your situation? Describe it in plain words and we will sort it out — or browse the rest of our Hickory services.
Materials, equipment and how we do tile roofing
The difference between tile roofing that lasts and tile roofing that gets redone in three years is almost always preparation and materials, not the finish you see on day one. We work with kickout diverters soldered rather than caulked at the wall termination, self-adhered membrane run across the full receiving plane, headwall flashing tucked behind the wall covering on a two-story elevation, three by four downspout outlets set at the low end of the lower run, spec them to the job instead of to the invoice, and write the material grades into the free estimate so you know exactly what you are buying.
Every Hickory job runs the same way: site walk and measurements, written scope and fixed price, protection of the surrounding area, then the work itself with a daily clean-up. Years of roofing work in Catawba County and the Unifour means we have already met whatever your property is going to throw at us — awkward access, older construction, an HOA with opinions.
Where we do tile roofing outside Hickory
Hickory Roof Pros covers Hickory and the surrounding communities of Catawba County and the Unifour. Crews run out to the same nearby cities every week, so an out-of-town job does not mean an out-of-town price.
- Tile Roofing in Newton, NC — Catawba County, population 13,148
- Tile Roofing in Conover, NC — Catawba County, population 8,421
- Tile Roofing in Long View, NC — Catawba County, population 5,088
- Tile Roofing in St. Stephens, NC — Catawba County, population 8,852
- Tile Roofing in Mountain View, NC — Catawba County, population 3,590
- Tile Roofing in Claremont, NC — Catawba County, population 1,692
Start on the Hickory Roof Pros homepage for a free estimate, or call (844) 511-2320 and describe the job.
Why Hickory Chooses Hickory Roof Pros
- ✓We grade planes, not roofs. A stacked Hickory house gets a separate condition note for each slope, and you keep that sheet whether or not you hire us.
- ✓Receiving planes get a membrane across the full field rather than the customary three-foot eave strip, because the water landing there does not stop three feet up.
- ✓Kickout diverters go on every roof-to-wall termination we build. They cost very little and they are missing from most of the brick-veneer stock in this county.
- ✓We will quote a partial replacement when the lower roof is finished and the field is not, and we will tell you plainly what the color mismatch will look like.
The standards behind tile roofing
Quality here is not a matter of opinion — it is written down. The tile roofing work we do in Hickory follows published industry standards: NRCA publishes the Roofing Manual, the industry's reference for details and slope minimums, and Asphalt Roofing Manufacturers Association sets the shingle application and ventilation guidance the warranties reference. If a contractor cannot tell you which standard a detail comes from, that is worth asking about before you sign.
Every tile roofing project in Hickory gets the same attention, whether it is a single room or a full commercial job. We show up on schedule, keep the site clean, and stand behind the work — the estimate is free and there is no pressure.
Ready to get started? Call (844) 511-2320 for a free tile roofing free estimate in Hickory, or request a quote and we'll get right back to you.